Tag Archives: OSHA

Do I Need a Swing Gate on My Fixed Ladder?

 

Walk-thru fixed ladder with cage

Walk-thru fixed ladder with safety cage

Do you need a ladder gate at your ladder opening in your railing? According to OSHA 1910.28(b)(3)(iv)“Each employee is protected from falling into a ladderway floor hole or ladderway platform hole by a guardrail system and toeboards erected on all exposed sides, except at the entrance to the hole, where a self-closing gate or an offset must be used.”

This means that every ladder opening needs to be either (a) Offset so that a person cannot walk (or fall) directly into the opening or (b) Protected by a ladder safety gate. It is an easy either/or. The most common ladder installation locations are not offset and as such require safety gates. Below you will see some photos of ladders and top view sketches clarifying why each of their orientations either do or do not require a gate. Note: ladder chains do not meet OSHA standards.

Another seemingly redundant standard from OSHA further increases the areas requiring gates is 1910.29(b)(13) and 1910.29(b)(13)(i): When guardrail systems are used around holes that serve as points of access (such as ladderways), the guardrail system opening: (1910.29(b)(13)(i) has a self closing gate that slides or swings away from the hole, and is equipped with a top rail and midrail or equivalent intermediate member(…). 

This standard opens up gate requirements to manhole covers, roof hatches and other similar systems that would remain open while accessed.

Now that we know what the code requirement is, it is time to review a few common ladder mounting orientations to discuss where they fall under the code.

Fixed ladder mounted to side of platform

Fixed ladder mounted to side of platform

The above fixed ladder is mounted onto the side of the platform. Work is performed further down the platform but it is possible to fall directly down the ladder opening. This location is not offset and as such would require a swing gate. See the below top view sketch for clarification.

Top view sketch of side mounted fixed ladderway opening

Top view sketch of side mounted fixed ladderway opening

You can walk directly to the ladder opening from where work is/can be expected to be performed and as such, a safety gate is required at the ladder opening.

Fixed ladder with offset landing platform

Fixed ladder with offset landing platform

The above ladder accesses a platform and then turns to access the main walkway. This ladder is offset and would not require a swing gate at the opening.

Top view sketch of offset mounted fixed ladderway opening

Top view sketch of offset mounted fixed ladderway opening

As you can see above, if someone fell while at the main walkway they would fall onto the ladder landing surface, they would not fall down the ladder opening. If the ladder was rotated to the left side of the landing it would require a safety gate because then the ladder opening would no longer be offset.

Ladderway opening on side of catwalk

Ladderway opening on side of catwalk

Above is a very common ladder mount position. This one can be tricky until you lay it out from the top view. From first glance it looks like because the ladder is off to the side that it would be offset from the normal flow of traffic, but if you fell at that point of the catwalk there would be no guarding to protect you. A swing gate is a requirement at this location.

Top view sketch of catwalk side mounted fixed ladderway opening

Top view sketch of catwalk side mounted fixed ladderway opening

As you can see from the above sketch, there is a single direction of travel to the ladder from the catwalk. This is not offset. It would be a single direction fall into the ladder opening and as such, a ladder safety gate is required to protect your employees when a ladder is installed in the above orientation.

Most areas are not offset. A good rule of thumb is that if you can fall into the ladder opening with a single direction fall, then you are not offset. The only example above that didn’t need a gate was the second ladder location. With that orientation, you would fall onto the ladder landing and then hit the rear railing, not fall through the ladder opening.

Outdoor Stairs for a Construction Trailer

How to get safe permanent access to a construction trailer

Wooden construction trailer stairs

Temporary wooden construction trailer stairs

Job site construction trailers are used all over. Some are temporarily placed in location and then relocated, and some are permanently stationed. The construction trailers can house offices, tools, machinery, electrical controls and more. Oftentimes, job site trailers will have temporary wooden stairs affixed, like the above photo. But what do you do when the construction trailer is actually in a permanent or semi-permanent location?

assembled metal stairs for construction trailer

Shop assembled job site stairs

We often get calls to fabricate replacement construction trailer stairs to replace temporary wooden steps. The stairs below were used with job site trailer that housed electrical control modules and needed a safe OSHA compliant means of access from two sides.

removable handrail on metal stairs

Close-up of removable handrail option

As the construction trailer had some large control modules inside, we supplied stair landings with handrails that can be unbolted, to allow ample access should any module need to be replaced. The stair railings were welded to the stair stringer to maintain a stiff, wobble-free grabbing surface.   In an effort to help keep costs down on the project, the stairs were supplied with two support columns instead of four. This was achieved by bolting the platform edge of the landing to the existing structure, allowing for less steel to be used and a smaller concrete pad to be poured.

stair landing with grating for snow

Bar grating decking allows dirt and snow to fall through – allowing for a safe, clear walking surface

Construction trailers are generally located outside in work zones, oftentimes lacking paved access to the doors. With that in mind, the stair treads and stair landing surfaces are most commonly constructed from bar grating. Bar grating is inherently self-cleaning; mud, dirt, rain and snow fall through the treads keeping them cleaner and safer to step on. The landing also has toe kick around the non-entry and exit locations. The 4” high toe guard stops tools and other items from being kicked off the landing. It also serves to stop a slipping foot from falling off the landing, potentially preventing a serious injury and employee downtime.

fully assembled construction trailer stair with galvanized finish for corrosion  protection

Construction trailer stair with a galvanized finish for superior corrosion resistance

As for finish, hot dipped galvanized is one of the best, cost effective finishes to use when the stairs will be exposed to the elements. No chipping, peeling or blistering of the coating will happen. In fact, when the hot dipped galvanized surface is scraped to bare steel, it will ‘self-heal’. The zinc rich galvanized surfaces to the sides of the bare metal will sacrifice themselves to protect the base steel until all of the surrounding zinc is consumed. Hot dipped galvanizing also coats 100% of the structure because it is immersed in the zinc solution, as opposed to being painted on, which can miss hard to reach areas.